Honda outboard info plzz

GROWLER

Well-known member
hi im after some info regarding servicing a honda bf30 outboard , iv tryed to use the boat today got right to the waters edge and found i had a fuel leak from the carbs probly down to a sticking float .... hence the need for service manual , anyone know where the best place is for servicing .

manual needed

i may have a go myself but a pro might come in handy .

any recommendations welcome help ,,, :D

cheers jay
 
honda outboard bf30

honda outboard bf30

Where are you based?


situated in newcastle near the tyne .... its looking like the float is stuck to the lack of pre winter service , ill learn the hard way .

any info regarding service repair would be good .

any recommendations on fuel /carb cleaner !


thanks ...
 
have you tried manual pumping excess fuel through with the primer bulb to free it?

crack the brass drain nut on the bottom of the suspect carb and pump the bulb while tapping the carb body (rubber mallet or something) then nip the drain nut up and see if it's any better

also be worth checking all the rubber fuel lines and clips to make sure there's no leaks/cracks
 
honda bf 30 sticky float ,,

honda bf 30 sticky float ,,

have you tried manual pumping excess fuel through with the primer bulb to free it?

crack the brass drain nut on the bottom of the suspect carb and pump the bulb while tapping the carb body (rubber mallet or something) then nip the drain nut up and see if it's any better

also be worth checking all the rubber fuel lines and clips to make sure there's no leaks/cracks

thanks for the reply im off outside now to get down and dirty .... :o

ill feed back my finding s thanks again .
 
update re sludge in carbs errr !

update re sludge in carbs errr !

ok managed to sort the outboard out had to strip the carbs down literaly and clean them with petrol ....
tryed knocking the bowl but with this amount of old dryed up petrol
i wouldnt think that would work .

the crap in the bottom of the carb bowl was :eek: holy moly .

took a few snaps to let you see whats what ....
1st this is where the petrol was leaking out of i take it its the carb overflow ..

090.jpg

now for the strip down ....
092.jpg

getting the thing apart was tricky ....
091.jpg

093.jpg


the carb bowl was realy bad no service by the looks ill have to get busy :)
and sort it out ready for some fishing ...

094.jpg


thanks a lot for the replys all good now, jay.:red:
 
Back
Top